Copper Ion Yarn for Tennis Dresses: Cost and Value Analysis
Odour control is an easy line item to cut and an expensive one to remove. This is the cost picture for tennis dresses built with Copper Ion Yarn.
What the finish adds
The direct cost is USD 0.45-0.75 per garment. Testing adds little, and the process usually runs inside an existing finishing or spinning step rather than as a separate operation. The sweat zone for tennis dresses is the built-in short and the chest band, which is where the treatment has to sit.
What it protects
The value sits in what does not happen: fewer stale-smell complaints on tennis dresses, fewer returns at the built-in short and the chest band, and a product that still smells clean after match play and club training. Every lot is measured against AATCC 100 antibacterial test before the fabric is released for cutting.
How long the value lasts
Measured performance runs to 30-50 washes depending on construction. Divide the cost by that number and the figure per wear is very small, provided the care label stating avoid bleach and dry away from direct heat is followed. Cost impact is USD 0.45-0.75 per garment, which is usually recovered through fewer returns across a season.
Where to spend and where to save
Spend on products worn between washes and on premium tiers. Save on occasional-wear styles, or use the system only in the panel that needs it, which cuts the add-on without losing the effect. Wear trials were run under match play and club training rather than in the laboratory alone.
How to compare quotes
Compare quotes only when both name AATCC 100 antibacterial test and the same target of bacterial reduction above 98% with improved thermal diffusion. A cheaper finish that is untested is not a saving, it is an unpriced risk on every shipment. The care label states avoid bleach and dry away from direct heat, and that wording is the condition behind 30-50 washes depending on construction.
